Heated Grip Kit

Home
Up

 

Heated grips is the question and our Dual Star Heated Grip Kit is the answer!

If you ride in wet or cold conditions you know that safety and control of the motorcycle can be severely compromised by cold aching hands. 

Keeping those paws warm increases endurance and riding enjoyment (many riders claim that heated grips help to reduce forearm pump which can result in numb hands and wrists). No need to wear big bulky gloves, now you will have no problem keeping your hands warm! This kit is on our top ten GOTTA-HAVE-IT list!!

Mylar tape-style dual stage heating element (4" x 2 3/4") wraps around and adheres permanently to the handlebar beneath handgrips to provide toasty comfort at high or low temperature settings. Extra long 32" insulated wires are then routed along existing cables/looms. These tricky little items allow you to use the handgrip of your choice! 12-volt system draws only 36 watts on the high position.

View Larger!

  • High quality 3-way toggle switch and connectors included

  • We use only 3M (VHB) Very High Bond adhesive

  • Design specific element wattage for each side

  • Hi-Low resistor has been eliminated! Yes!

  • Does not require a battery in the system

  • Compatible with our excellent Grip Cement

  • Extra long 32" insulated wires!

Replacement elements are available if you need them...

With the exception of warranty related claims, there are absolutely no returns, exchanges or adjustments on this product.

ITEM #

PRODUCT DESCRIPTION

RETAIL

QTY

20-10001-175

DUAL STAR HEATED GRIP KIT

$34.95

KIT

Water Proof Toggle Boot
EPDM Rubber Boot with 15/32-32 thread. Provides protection against spray and is resistant to weather and ozone. This boot usually replaces the top switch nut.
Heavy Wall Shrink Tube
This triple-wall adhesive lined (as shown in the cut-away photo) polyolefin tubing is highly recommended for insulating the left side of heat-sucking aluminum handlebars. When heat is applied it will bond permanently to your handlebar.

We recommend using an additional THROTTLE GRIP over this material on the left side as it is approximately the same diameter as your throttle tube on the right.

This material is not required for steel handlebars!

Round Rocker Switch
The High-OFF-Low flush mount alternative to our stock toggle switch. This is a popular option if you have flat panel area on your vehicle.

Although this switch is NOT water proof it holds up very well in wet weather.

Don't forget the grip cement! This is the best grip glue we have found and is highly recommended to bond your grips to the heating elements/handlebar.

Caution! We do not recommend Stainless Steel wire to secure your hand grips when using the Dual Star Grip Heaters!

 

ITEM #

PRODUCT DESCRIPTION

RETAIL

QTY

20-10001-180

WATER PROOF SWITCH BOOT $3.95 EA

20-10001-176

HEAVY WALL SHRINK TUBE $4.25 EA

20-10001-182

ROUND ROCKER SWITCH $3.95 EA

21-05101

THREE BOND GRIP CEMENT

$7.95

EACH

 

View Larger...

Our optional Heat-troller™ is a DC (direct current), power controller designed for use with our heated grips. It would replace the basic three way toggle switch included in our kit shown above.

You can think of the Heat-troller as a dimmer switch for your heated grips. It has a positive off and provides a full range of heat that is constant at any setting, just as a light dimmer switch gives you constant light at different levels.

The "Dash Mount" style is designed for motorcycles with fairings or other suitable locations to which the control knob can be installed (hiding the small circuit board behind the panel).

The "Velcro Mount" style is designed for Dual Sport, Adventure Touring and "naked" motorcycles that do not have a suitable place to install the control knob/circuit board. Instead, a very small box (1.5" L x 1.3" W x .9" H) houses the circuit board which allows you to mount it just about anywhere on the bike with the use of the supplied Velcro.

With the exception of warranty related claims, there are absolutely no returns, exchanges or adjustments on this product.

ITEM #

PRODUCT DESCRIPTION

RETAIL

QTY

40-19800-000

HEAT-TROLLER DASH MOUNT

$49.95

KIT

40-19800-001 HEAT-TROLLER VELCRO MOUNT

$59.95

KIT

 

Monday-Friday  11:00AM-6:00PM Pacific Standard Time

 
 
DUAL STAR……The original Motorcycle Adventure Outfitters. Providing the highest quality and most innovative Serious Trail And Road accessories, clothing and equipment to the motorcycle enthusiast around the world!
All original material, photographs, images, text, logos and HTML Coding - Copyright © 1986-2012 DUAL STAR INTERNATIONAL  All rights reserved.       
Send mail to the WEBMASTER with questions or comments about the operation of this web site.
DUAL STAR, DUAL STAR INTERNATIONAL, Serious Trail And Road, Motorcycle Adventure Outfitters, AdventureGear, Adventure Gear, Tarmac To Timberline, TrickStar, TrailStar, TrailMax, TrailTech, Trail Tested, S.T.A.R. Tech, GO-N-RIDE, 1-800-GO-N-RIDE and 1-866-GO-N-RIDE are trademarks of DUAL STAR INTERNATIONAL
All other names and logos are the trademarks of their respective owners.
Prices, specifications and product availability subject to change without notice.
Last modified: March 09, 2012